Kia Soul: Front Washer Motor Removal - Windshield Wiper/Washer - Body Electrical SystemKia Soul: Front Washer Motor Removal

Kia Soul 2014-2019 PS Service Manual / Body Electrical System / Windshield Wiper/Washer / Front Washer Motor Removal

  
-
When servicing the washer pump, be careful not to damage the washer pump seal.
-
Do not operate the washer pump before filling the washer reservoir.
Failure to do so could result in premature pump failure.
1.
Disconnect the negative (-) battery terminal.
2.
Remove the front bumper cover.
(Refer to Body - "Front Bumper Cover")
3.
Disconnect the washer motor connector (A), after removing washer hose.
55555
4.
Remove the reservoir (A) after loosening 2 bolts.
    Front Washer Motor Inspection
    1. With the washer motor connected to the reservoir tank, fill the reservoir tank with water.    ...

    Front Washer Motor Installation
    1. Reassemble the washer reservoir. Tightening torque: 6.9 ~ 10.8Nm (0.7 ~ 1.1, kgf.m, 5.0 ~ 7.9 lb-ft) ...

    See also:

    Lubricants
    Items  Specified lubricants  Quantity Clutch release cylinder assembly Brake fluid DOT 3 or DOT 4  As required Clutch pedal ...

    Front Door Outside Handle Replacement
    1. Remove the hole plug (A). 2. After loosening the mounting bolt, then remove the front door outside handle cover (B). ...

    TJ Joint Installation
    1. Wrap tape around the driveshaft spline(TJ) to prevent damage to the boot. 2. Using the alignment marks (D) made during disassembly as a ...