Kia Soul: Installation - Seat Belt Pretensioner - RestraintKia Soul: Installation

Kia Soul 2014-2019 PS Service Manual / Restraint / Seat Belt Pretensioner / Installation

1.
Remove the ignition key from the vehicle.
2.
Disconnect the battery negative cable and wait for at least thirty seconds.
3.
Install the seat belt pretensioner with bolt (B).
Tightening torque :
39.2 ~ 53.9 N.m (4.0 ~ 5.5 kgf.m, 28.9 ~ 39.8 lb-ft)

4.
Connect the seat belt pretensioner connector (A).
5.
Install the front seat belt upper anchor (A).
Tightening torque :
39.2 ~ 53.9 N.m (4.0 ~ 5.5 kgf.m, 28.9 ~ 39.8 lb-ft)

6.
Install the center pillar upper trim.
(Refer to Body - "Center pillar trim")
7.
Install the center pillar lower trim.
(Refer to Body - "Center pillar trim")
8.
Insert the seat belt to the emergency fastening device (A).

  
Make sure the lock pin is connected in properly.
9.
Reconnect the battery negative cable.
10.
After installing the seat belt pretensioner, confirm proper system operation:
A.
Turn the ignition switch ON; the SRS indicator light should be turned on for about six seconds and then go off.
    Removal
    1. Disconnect the battery negative cable, and wait for at least thirty seconds before beginning work. 2. To remove the emergency fastening ...

    Emergency Fastening Device (EFD). Description
    Emergency Fastening Device (EFD) is deployed with Belt Pretensioner at the same time to pull down the seat belt strongly If it gets into its deploy condition after a collision. It is located ...

    See also:

    Ignition Coil Inspection
    1. Measure the primary coil resistance between terminals (+) and (-). Standard value: 0.79Ω В± 15% ...

    Condenser Inspection
    1. Check the condenser fins for clogging and damage. If clogged, clean them with water, and blow them with compressed air. If bent, gently bend them using a screwdrive ...

    ISG (Idel Stop and Go) system
    Your vehicle may be equipped with the ISG system, which reduces fuel consumption by automatically shutting down the engine, when the vehicle is at a standstill. (For example : red light, stop sign ...