Kia Soul: Rear Disc Brake. Replacement - Brake System - Brake System - Kia Soul 2014-2019 PS Service ManualKia Soul: Rear Disc Brake. Replacement

Second generation PS (2014-2019) / Kia Soul 2014-2019 PS Service Manual / Brake System / Brake System / Rear Disc Brake. Replacement

Rear brake pads
1.
Remove the front wheel & tire.
2.
Loosen the guide rod bolt (B) and the remove the rear caliper body (A).

Tightening torque :
21.6 ~ 31.4 N.m (2.2 ~ 3.2 kgf.m, 15.9 ~ 23.1 lb-ft)

3.
Replace pad retainers (C) and brake pads (B) in the caliper carrier (A).

4.
Rotate the caliper piston and push the direction of the arrow.

5.
Place the caliper body (A) on the caliper carrier and tighten the guide rod bolt (B).

Tightening torque :
21.6 ~ 31.4 N.m (2.2 ~ 3.2 kgf.m, 15.9 ~ 23.1 lb-ft)

  
Assemble the caliper body so that the piston groove (A) is in-line with the pad center lobe (B).

* Make sure that the piston and pad are tightly attached.
6.
Install the front wheel & tire.

Tightening torque :
88.3 ~ 107.9 N.m (9.0 ~ 11.0 kgf.m, 65.1 ~ 79.6 lb-ft)

    Rear Disc Brake. Removal
    Brake caliper assembly 1. Remove the front wheel & tire. Tightening torque : 88.3 ~ 107.9 N.m (9.0 ~ 11.0 kgf.m, 65.1 ~ 79.6 lb-ft ...

    Rear Disc Brake. Inspection
    Rear brake disc thickness check 1. Check the brake pads for wear and fade. 2. Check the brake disc for damage and cracks. ...

    See also:

    Engine compartment
    1. Windshield washer fluid reservoir 2. Engine oil filler cap 3. Engine oil dipstick 4. Engine coolant reservoir 5. Radiator cap 6. Brake/clutch fluid reservoir 7. Positive battery terminal ...

    Snow tires
    If you equip your car with snow tires, they should be the same size and have the same load capacity as the original tires. Snow tires should be installed on all four wheels; otherwise, poor handli ...

    Change to "winter weight" oil if necessary
    In some climates it is recommended that a lower viscosity "winter weight" oil be used during cold weather. See section 8 for recommendations. If you aren't sure what weight oil you s ...