Kia Soul: Front Wiper Motor Installation - Windshield Wiper/Washer - Body Electrical SystemKia Soul: Front Wiper Motor Installation

Kia Soul 2014-2019 PS Service Manual / Body Electrical System / Windshield Wiper/Washer / Front Wiper Motor Installation

1.
Install the wiper motor.
2.
Install the crank arm.
  
To install the wiper motor crank arm, make sure that the linkage is aligned with the crank arm in straight line and set the angle of each linkages exactly.
3.
Install the lower and upper linkage to the wiper motor crank arm.
  
To install the wiper motor crank arm, make sure that the linkage is aligned with the crank arm in straight line and set the angle of each linkages exactly.
Be careful not to bend the linkage.
4.
Install the wiper motor and linkage assembly and then connect the wiper motor connector.

Tightening torque:
6.9 ~ 10.8Nm (0.7 ~ 1.1, kgf.m, 5.0 ~ 7.9 lb-ft)

5.
Install the cowl top cover.
6.
Install the windshield wiper arm and blade.

Tightening torque:
22.6 ~ 26.5 Nm (2.3 ~ 2.7 kgf.m, 16.6 ~ 19.5 lb-ft)

  
-
The windshield wiper motor must be cycled to make sure that it is in the auto stop position.
If necessary, adjust the wiper arm and blade.
7.
Install the wiper arm and blade to the auto stop position.
A : Auto stop position (Blade)

    Front Wiper Motor Removal
    1. Loosen the windshield wiper arm nut (B) after removing a wiper cap (A). 2. Remove the windshield wiper arm an ...

    Front Wiper Motor Inspection
    Speed Operation Check 1. Disconnect the connector (A) from the wiper motor. 2. Attach the positive (+) lead from ...

    See also:

    Inspection
    Test the horn by connecting battery voltage to the 1 terminal and ground the 2 terminal. The horn should make a sound. If the horn fails to make a sound, replace it. ...

    Master Cylinder. Removal
    Master Cylinder assembly 1. Turn ignition switch OFF and disconnect the negative (-) battery cable. 2. Remove the ECM. (Refer ...

    Seat Heater Switch Components
    [First Row Seat] Connector Pin Information Connector Pin NO Function Connector Pin NO Function A ...