Kia Soul: Condenser Replacement - Air conditioning System - Heating,Ventilation And Air ConditioningKia Soul: Condenser Replacement

Kia Soul 2014-2019 PS Service Manual / Heating,Ventilation And Air Conditioning / Air conditioning System / Condenser Replacement

1.
Recover the refrigerant with a recovery/recycling/charging station.
2.
Disconnect the negative (-) battery terminal.
3.
Remove the front bumper.
(Refer to Body - "Front Bumper Cover")
4.
Remove the head lamps.
(Refer to Body Electrical System - "Head Lamps")
5.
Remove the 2 nuts, and then disconnect the discharge line (A) and liquid line (B) from the condenser.
Tightening torque :
4.9 ~ 7.8 N.m (0.5 ~ 0.8 kgf.m, 3.6 ~ 5.7 lb-ft)

6.
Remove the radiator reservoir tank hose mounting clip (A).
7.
Remove the hood latch release handle cable (A).
8.
Loosen the mounting bolts and then remove the radiator upper bracket (A).
9.
Make a gap for removing the side air guard by moving the condenser and radiator (A) back.
10.
Remove the side air guard (A) by pulling it upwards.
[LH]

[RH]
11.
Remove the condenser (A) from radiator.
12.
Install in the reverse order of removal.
  
•
If you're installing a new condenser, add refrigerant oil.
•
Replace the O-rings with new ones at each fitting, and apply a thin coat of refrigerant oil before installing them. Be sure to use the right O-rings for R-134a to avoid leakage.
•
Be careful not to damage the radiator and condenser fins when installing the condenser.
•
Charge the system, and test its performance.
    Condenser Inspection
    1. Check the condenser fins for clogging and damage. If clogged, clean them with water, and blow them with compressed air. If bent, gently bend them using a screwdrive ...

    Receiver-Drier Replacement
    1. Remove the condenser. 2. Remove the cap (B) on the bottom of the condenser with a L wrench (A). Tightening to ...

    See also:

    Driving your vehicle
    WARNING - ENGINE EXHAUST CAN BE DANGEROUS! Engine exhaust fumes can be extremely dangerous. If, at any time, you smell exhaust fumes inside the vehicle, open the windows immediately. Do not inh ...

    SRS Control Module (SRSCM). Removal
    1. Remove the ignition key from the vehicle. 2. Disconnect the battery negative cable and wait for at least three minutes before beginning ...

    Customer Complaint Analysis Check Sheet
    Troubleshooting (Flow chart type) There are six areas where a problem can occur: wiring harness, the radio, the USB/iPod, and speaker. Troubleshooting enables you to confine ...