Kia Soul: Repair procedures - Panorama Sunroof - Body (Interior and Exterior)Kia Soul: Repair procedures

Kia Soul EV (PS EV) 2015-2020 Service Manual / Body (Interior and Exterior) / Panorama Sunroof / Repair procedures

Adjustment
Inspect Glass Alignment
1.
Inspect the alignment of the movable glass (C) that is between the front (A) and rear (B) glass and if needed adjust it.

Alignment adjustment
Standard value [mm(in.)]
(1) Front edge : 0 mm (0 in.)
(2) Rear edge : 0 mm (0 in.)

2.
Completely open the movable glass using the panorama sunroof switch.
3.
Remove both sides of the decoration cover (A) by pulling it in the direction of the arrow.

4.
Completely close the movable glass using the panorama sunroof switch.
5.
Adjust the height of the glass by slighty loosening the screws (A).
   
•
Be careful not to damage the screw.

Emergency operation
1.
Use the panorama sunroof emergency operation only when you have to open or close the sunroof when there is a problem with the engine.
2.
Use a hexagon wrench to open or close the panorama sunroof after removing the roof trim. Do not apply too much force when opening or closing the panorama sunroof.
[Movable Glass Motor ]

[Roller Blind Motor]

3.
If needed reset the panorama sunroof according to the reset method.
    Components and Components Location
    Components 1. Roof side moulding [LH]2. Roof side moulding [RH]3. Movable glass 4. Wind deflector5. Decoration cover [LH]6. Decoration cover [RH]7. Center cover8. Panorama sunroof frame assembly9 ...

    Movable Glass Repair procedures
    Replacement 1. Completely open the movable glass using the panorama sunroof switch. 2. Remove both sides of the decoration cover (A) by pulling it in the direction of the arrow. 3. Comple ...

    See also:

    Curtain Airbag (CAB) Module Components and Components Location
    Components ...

    Pre-Charge Registor Schematic Diagrams
    System Circuit Diagram With High Votlage Battery Heater System Without High Voltage Battery Heater System Circuit Diagram Without High Voltage Battery Heater System With High Voltage Batt ...

    External Amplifier Installation
    1. Install the external amplifier after connecting the connector.    ...