Kia Soul: Curtain Airbag (CAB) Module Repair procedures - Airbag Module - RestraintKia Soul: Curtain Airbag (CAB) Module Repair procedures

Kia Soul EV (PS EV) 2015-2020 Service Manual / Restraint / Airbag Module / Curtain Airbag (CAB) Module Repair procedures

Removal
1.
Disconnect the battery negative cable and wait for at least thirty seconds before beginning to work.
2.
Remove the roof trim assembly.
(Refer to Body - "Roof trim assembly")
3.
Disconnect the curtain airbag harness connector (A).

4.
After loosening the mounting bolts and nuts remove the curtain airbag.
Installation
1.
Remove the ignition key from the vehicle.
2.
Disconnect the battery negative cable and wait for at least thirty seconds.
3.
Tighten the curtain airbag mounting bolts and nuts.
Tightening torque
Bolt : 7.8 ~ 11.8 N.m (0.8 ~ 1.2 kgf.m, 5.8 ~ 8.7 lb-ft)
Nut : 3.9 ~ 5.9 N.m (0.4 ~ 0.6 kgf.m, 2.9 ~ 4.3 lb-ft)
   
•
Never twist the airbag module during installation as twisted module may result in abnormal operation. (of the airbag module.)
4.
Connect the curtain airbag connector.
5.
Install the roof trim assembly.
(Refer to Body - "Roof trim assembly")
6.
Reconnect the battery negative cable.
7.
After installing the curtain airbag (CAB), confirm proper system operation:
•
Turn the ignition switch ON; the SRS indicator light should be turned on for about six seconds and then go off.
    Curtain Airbag (CAB) Module Components and Components Location
    Components ...

    Airbag Module Disposal Description and Operation
    Airbag Disposal Special tool required Deployment tool 0957A-34100A Before scrapping any airbags or side airbags (including those in a whole vehicle to be scrapped), the airbags or side airba ...

    See also:

    Brake Booster. Inspection
    1. Inspect the check valve in the vacuum hose.    Do not remove the check va ...

    Parking brake
    Checking the parking brake Check the stroke of the parking brake by counting the number of “clicks’’ heard while fully applying it from the released position. Also, the parking brake alon ...

    Wipers and washers
    Windshield wiper/washer Rear window wiper/washer A : Wiper speed control · MIST – Single wipe · OFF – Off · INT – Intermittent wipe · LO – Low wiper speed · HI – High wiper s ...